Colonial Pipeline - Safety and Environmental Record

Safety and Environmental Record

Colonial received the API’s Distinguished Environmental and Safety award four consecutive years (1999-2002).

In 2005, Hurricane Katrina knocked out power in large parts of Mississippi and Louisiana, forcing Colonial to operate at reduced flow rates. Portable generators were rented and helped restore partial service as utilities recovered and restored normal service. When Hurricane Rita hit a month later, Colonial used these generators to help load product stranded in refinery storage tanks which did not have power. By the time hurricanes Gustav and Ike struck in 2008, Colonial owned and operated this set of emergency generators. A new set of generators was purchased in 2012 and is stationed in Mississippi, inland and out of the direct path of most storms.

Spill History:

Early on September 2, 1970, residents of Jacksonville, Maryland, detected gasoline odors and noticed gasoline in a small creek flowing beneath a nearby road. Because fumes were still present in the late afternoon of September 2, a resident notified Colonial at 6:19 p.m. about the situation. Colonial, which had a 30-inch-diameter pipeline situated about 1,700 feet east of the point where the creek passed under the road, shut down the Dorsey Junction, Maryland, pump station (the initial pump station for this section of the pipeline) at 6:34 p.m. About 12 hours later, on the morning of September 3, an explosion and fire occurred in a ditch in which contractor personnel for Colonial were manually digging to further expose the pipeline and catch gasoline trickling from the ground. Five persons were injured, none fatally. The leak point was found 4 days later. The failure resulted in a release of 30,186 gallons (718 barrels) of gasoline and kerosene.

At 9:51 p.m. on December 19, 1991, Colonial's Line 2, a 36-inch-diameter petroleum products pipeline, ruptured about 2.8 miles downstream of the company's Simpsonville, South Carolina, pump station.7 The rupture allowed more than 500,000 gallons (13,100 barrels) of diesel fuel to flow into Durbin Creek, causing environmental damage that affected 26 miles of waterways, including the Enoree River, which flows through Sumter National Forest. The spill also forced Clinton and Whitmire, South Carolina, to use alternative water supplies.

On Sunday, March 28, 1993 at 8:48 a.m., a pressurized 36-inch-diameter (910 mm) petroleum product pipeline owned and operated by Colonial Pipeline Company ruptured near Herndon, Virginia. The rupture created a geyser which sprayed diesel fuel over 75 feet (23 m) into the air, coating overhead power lines and adjacent trees, and misting adjacent Virginia Electric Power Company buildings. The diesel fuel spewed from the rupture into an adjacent storm water management pond and flowed overland and through a network of storm sewer pipes before reaching Sugarland Run Creek, a tributary of the Potomac River.

In 1996, a 36 inch diameter Colonial pipeline ruptured at the Reedy River, near Fork Shoals, South Carolina, June 26. The ruptured pipeline released about 957,600 US gallons (3,625,000 L) of fuel oil into the Reedy River and surrounding areas. The spill polluted a 34-mile (55 km) stretch of the Reedy River, causing significant environmental damage. Floating oil extended about 23 miles (37 km) down the river. Approximately 35,000 fish were killed, along with other aquatic organisms and wildlife. The estimated cost to Colonial Pipeline for cleanup and settlement with the State of South Carolina was $20.5 million. No one was injured in the accident. The pipeline was operating at reduced pressure due to know corrosion issues, but pipeline operator confusion led to an accidental return to normal pressure in that pipeline section, causing the rupture.

In 1997 On May 30, Colonial Pipeline spilled approximately 18,900 US gallons (72,000 L) of gasoline, some of which entered an unnamed creek and its adjoining shoreline in the Bear Creek watershed near Athens, Georgia. During the spill, a vapor cloud of gasoline formed, causing several Colonial employees to flee for safety. This spill resulted from a calculation error related to a regular procedure. No one checked the calculations, nor did Colonial have a procedure in place to check such calculations.

On Wednesday, October 3, 2012, Colonial Pipeline shut down line 19 and 20 in Chattanooga, Tennessee due to reports of gasoline odors. It was reported that about 500 gallons of gasoline may have been released. The line carrying gasoline was repaired and the distillate line, which carries diesel fuel, jet fuel and other products, was inspected and found to be undamaged. Both lines were restarted two days later on October 5, 2012.